skip to main content

Listen

Read

Watch

Schedules

Programs

Events

Give

Account

Donation Heart Ribbon

Boxer Presses NRC On Questions At Calif. Nuke Plant

California Sen. Barbara Boxer asked federal regulators Tuesday for details about the troubled steam generators at the San Onofre nuclear power plant, where a long-running probe into tube damage has kept the reactors sidelined for months.

In a letter, the Democrat asked Nuclear Regulatory Commission Chairman Gregory Jaczko for documentation on design changes to the generators made in 2009 and 2010, when they were installed at the seaside plant, and how the federal agency reviewed those modifications.

At issue is whether Southern California Edison sidestepped any federal requirements by conducting extensive modifications, a claim leveled by an environmental group that said the design changes are at the heart of the plant's problems.

The twin reactors, located between San Diego and Los Angeles, have been shut down for more than three months while investigators look into unusual damage to hundreds of tubes inside the massive generators.

"Concerns have been raised that design changes in the steam generators contributed to accelerated wear in tubes carrying radioactive water," Boxer wrote in a similar letter to SCE parent Edison International, which also requested documents. "The determination to restart the San Onofre reactors must ensure the safety of the millions of Californians who live and work near the plant."

Edison said in a statement Monday that "the NRC was fully informed that the replacement would be conducted under the same regulations as had been previously applied at other plants."

The 13-page report issued by Friends of the Earth warned that running the nuclear plant at reduced power would not resolve problems with badly worn tubing. Earlier this month the company announced a tentative plan to restart and run the seaside reactors at lower power, at least for several months, because engineers believe that will ease vibration that could be causing unusual wear in the tubes.

The generators function something like a car radiator, which controls heat in a vehicle's engine. The generator tubes circulate hot, radioactive water from the reactors, which heat a bath of non-radioactive water surrounding them. That makes steam, which is used to turn turbines to make electricity.

The tubes represent a critical safety barrier - if a tube breaks, there is the potential that radioactivity can escape into the atmosphere. Also, serious leaks can drain protective cooling water from a reactor.

The four generators each have nearly 10,000 alloy tubes that carry radioactive water. The report also expanded an earlier allegation that Southern California Edison misled federal regulators about the modifications, a charge disputed by the Nuclear Regulatory Commission and the company.

The trouble began to unfold in January, when the Unit 3 reactor was shut down as a precaution after a tube break. Traces of radiation escaped at the time, but officials said there was no danger to workers or neighbors. Unit 2 had been taken offline earlier that month for maintenance, but investigators later found unexpected wear on hundreds of tubes in both units.

The NRC has said there is no timetable to restart the reactors, as investigators continue to look for the cause of the unusual tube wear.

The report, written by Vermont-based nuclear consultants Fairewinds Associates, suggested the best alternatives might be scrapping and replacing the costly equipment, or spending as much as $400 million on an extensive repair.

The generators were replaced in 2009 and 2010 in a $670 million overhaul.

"Power reductions do not solve underlying and serious degradation problems," said the report. It warned of possible tube breaks that could endanger public health.

It said running at lower power would not prevent damaged tubes and tube supports from vibrating and damaging others nearby. "It will worsen the existing damage," the report concluded.

Gradual wear is common in such tubing, but the rate of erosion at San Onofre alarmed officials since the equipment is relatively new. The company last week said more than 1,300 tubes will be taken out of service, a far higher number than previously disclosed, but that number is well within the margin to allow the generators to keep operating.

Edison has been facing pressure from some nearby communities and nuclear activists who have raised safety concerns, while the company looks for a solution to the tube problem and a path to restarting the plant, an important source of power in Southern California. State officials have warned of possible power shortages in the region this summer while the plant remains dark.

The generators were designed to meet a federal test to qualify as "in-kind," or essentially identical, replacements, which allowed them to be installed without prior approval from federal regulators.

The report said a string of complex modifications involving tubes and supports should have triggered a more extensive review by the government, including public hearings, but did not. The report speculated that the NRC would have identified problems with the design if a thorough review was conducted.

"Edison should never have been allowed to install these fundamentally defective steam generators," Damon Moglen, climate and energy campaign director at Friends of the Earth, said in a statement. "Now Edison is planning to avoid dealing with the underlying problems and instead restart at lower power. Their claims of nuclear safety first ring completely hollow and must be stopped."

In a statement, NRC spokesman Victor Dricks said the company informed the agency of the steam generator design changes "in accordance with NRC requirements," and that portions of the design were reviewed by federal inspectors during the installation. He added that a team of investigators is reviewing those changes as part of its probe into tube wear at the plant.

Comments

Avatar for user 'Dr_Atom'

Dr_Atom | November 6, 2012 at 2:41 p.m. ― 2 years, 1 month ago

Radioactive leaks due to rupture of prematurely degraded metal tubing have released an undisclosed amount of radioactivity from Unit 3 of the San Onofre Nuclear Generating Station. The same deterioration has been found in unit 2. Leaks like these can lead to massive radiation escape by draining cooling water from the reactors, rapidly causing collapse of containment. Radiation release from San Onofre could endanger 8.4 million people living within 50 miles. A smaller leak could close Camp Pendleton, threatening national security. The cause of the premature aging of the metal tubing is not understood. Previous seismic safety models must now be called into question. San Onofre's Unit 1 reactor operated from 1968 to 1992 and was closed after 24 years. Units 2 and 3 have been operating for nearly 30 years, since 1982 and 1983, respectively. These aged reactors need to be closed. NRC’s once- or twice-a-year cursory inspections are not sufficient to ensure safety of these aging reactors. Any attempts to repair these aged reactors endanger workers known as jumpers who absorb large doses of radiation, sometimes a year’s worth of permissible exposure, in a short-time. Medically, it is not known if this is actually a safe practice. Shut down these aging reactors permanently before the human cost for this power becomes too high. Please sign the petition link below.

http://www.change.org/petitions/nuclear-regulatory-commission-permanently-shut-down-aged-san-onofre-nuclear-reactors

( | suggest removal )